MX100GT78

3.PLC控制系统中电磁干扰的主要来源有哪些呢？

  (1)来自空间的辐射干扰

  空间的辐射电磁场（EMI）主要是由电力网络、电气设备的暂态过程、雷电、无线电广播、电视、雷达、高频感应加热设备等产生的，通常称为辐射干扰，其分布极为复杂。若PLC系统置于所射频场内，就回收到辐射干扰，其影响主要通过两条路径；一是直接对PLC内部的辐射，由电路感应产生干扰；而是对PLC通信内网络的辐射，由通信线路的感应引入干扰。辐射干扰与现场设备布置及设备所产生的电磁场大小，特别是频率有关，一般通过设置屏蔽电缆和PLC局部屏蔽及高压泄放元件进行保护。

  (2)来自系统外引线的干扰

  主要通过电源和信号线引入，通常称为传导干扰。这种干扰在我国工业现场较严重。

  (3)来自电源的干扰

  实践证明，因电源引入的干扰造成PLC控制系统故障的情况很多，笔者在某工程调试中遇到过，后更换隔离性能更高的PLC电源，问题才得到解决。

  PLC系统的正常供电电源均由电网供电。由于电网覆盖范围广，将受到所有空间电磁干扰而在线路上感应电压和电路。尤其是电网内部的变化，入开关操作浪涌、大型电力设备起停、交直流转动装置引起的谐波、电网短路暂态冲击等，都通过输电线路到电源边。PLC电源通常采用隔离电源，但其机构及制造工艺因素使其隔离性并不理想。实际上，由于分布参数特别是分布电容的存在，隔离是不可能的。

  (4)来自信号线引入的干扰

  与PLC控制系统连接的各类信号传输线，除了传输有效的各类信号之外，总会有外部干扰信号侵入。此干扰主要有两种途径：一是通过变送器或共用信号仪表的供电电源串入的电网干扰，这往往被忽略；二是信号线受空间电磁辐射感应的干扰，即信号线上的外部感应干扰，这是很严重的。由信号引入干扰会引起I/O信号工作异常和测量精度大大降低，严重时将引起元器件损伤。对于隔离性能差的系统，还将导致信号间互相干扰，引起共地系统总线回流，造成逻辑数据变化、误动和死机。PLC控制系统因信号引入干扰造成I/O模件损坏数相当严重，由此引起系统故障的情况也很多。

Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Robotron 14509 Power Supply Assembly LST-37-133 5V / +12V / -12V
Pre-Owned
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Ronan Engineering X501N-102 Slot Rack Chassis Module
Pre-Owned
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   CEAG 86-264AC890CO-25DC-60Hz Power Supply Assembly 25  5VDC 35A
Pre-Owned
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   RS Pro 504228 Isolating Transformer +15–0–230-400V/0-230V 500VA 2  5A
Pre-Owned
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Kistler-Morse Power Supply Controller Enclosure 63-1155-01 ISI-100-ISBW
Pre-Owned
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Rosemount 183R22J2A30N040 Model 79 Temperature Sensor No Box
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Rosemount 183R22J2A30A050T34 Model 79 Temperature Sensor No Box
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Wilmar 1840DDBX-A Dead Bus Type Paralleling Relay 460VAC
Pre-Owned
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW TOG 195B931P0002 Turbine Guide Fitting VC01767
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Box of 25 Capitol MFG 90 FS 3M SW ELL Forged Steel 3/4" Elbow Pipe Fittings
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   250 Amp Max GE SPECTRA RMS Circuit Breaker SFHA36AT2225C 600 Volt 3 Pole
Pre-Owned
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW ABB 3HNM06855-1 Purge Sensor 3HNM 00272-1
Brand New
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   250 Amp GE SPECTRA RMS Circuit Breaker SFHA36AT2250C 600 VAC 3 Pole
Pre-Owned
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   idec IBRC4102FM IZBARL Contact Signal Transducer
Pre-Owned
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Macro Sensors LVC-2401 Low Voltage Conditioner Module
   1  737  47
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Westinghouse Emerson 1C31233G04 Ovation Events Input   Contact Module
Pre-Owned
   1  727  05
Was:  Previous Price   2  467  21
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fisher Rosemount CL6824X1-A2 Provox Smart Device Analog Input Card Rev   H
Pre-Owned
   1  727  05
Was:  Previous Price   2  467  21
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fanuc A06B-6066-H235 Dual Axis AC Servo Amplifier C Series No Door
Pre-Owned
   1  702  73
Was:  Previous Price   2  432  46
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ABB SimpleTech 3HAC 16917-1/02 2  5" Flash Drive Missing Connector
Pre-Owned
   1  702  73
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51304516-200 UCN Smart MV Xmtr Interface Card HDW: H FW: B
Pre-Owned
   1  702  73
Was:  Previous Price   2  432  46
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   General Electric 6BA07 Receiver Board DS3800HXRA1F1F
Pre-Owned
   1  702  73
Buy It Now
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Moore Products Co   16170-1-8 Voltage Input Module Termination Assembly
Pre-Owned
   1  702  73
Was:  Previous Price   2  432  46
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ABB DSQC 346U Servo Drive Unit 3HAB8101-13/08C S4C+
Pre-Owned
   1  702  73
Was:  Previous Price   2  432  46
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ABB DSQC 346U Servo Drive Unit 3HAB8101-13/08A S4C+
Pre-Owned
   1  702  73
Was:  Previous Price   2  432  46
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ABB DSQC 346U Servo Drive Unit 3HAB8101-13/07B S4C+
Pre-Owned
   1  702  73
Was:  Previous Price   2  432  46
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fanuc A06B-6066-H006 AC Servo Amplifier Unit Series C w/o Door
Pre-Owned
   1  702  73
Was:  Previous Price   2  432  46
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Weir Minerals C024G01 End Cover
   1  667  98
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Keckley 1-1/4" Angle Globe Float Valve Type 27 Globe Pattern No Box
   1  667  98
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   General Electric CR306E0**ABNA NEMA Size 3 Contactor 25-50 HP 460-480V Coil
Pre-Owned
   1  650  60
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Bently Nevada 21747-085-00 7200 Series Probe Cable
   1  650  60
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Cutler Hammer C0300C2AFB Single Phase Control Transformer   300 kVA
   1  650  60
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Fafnir 5311W BR Angular Contact Roller Bearing
   1  650  60
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Timken 95500 95925 Tapered Roller Bearing Cup & Cone Set
   1  633  23
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Square D 8536SEO1 NEMA Size 3 Motor Starter Contactor 120V Coil
Pre-Owned
   1  633  23
  
Free Shipping
Only 1 left!
6 Sold
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Square D PE16CT2 Micrologic Series 3 Neutral Current Transformer 1600A
Pre-Owned
   1  633  23
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Barber Colman 80GA-10103-001-V-00 Heat/Cool Module
Pre-Owned
   1  633  23
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   LMI Milton Roy AA151-392SI Metering Pump 1  00 GPH
Pre-Owned
   1  633  23
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Bently Nevada 72201-03-04-05-04-01-07 Control Board PWB 72203-01
Pre-Owned
   1  633  23
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Westinghouse 405A689G03 Ovation Disc Controller Board Sub   4
Pre-Owned
   1  633  23